- Step one: Lay down a tarp on the floor underneath the damaged ceiling. Cover any other surfaces as needed.
- Step two: Use a putty knife to scrape off the damaged popcorn texture.
How do you install ceiling panels on a mobile home?
Ceiling Panel with Channel System. A channeled ceiling divider is another way to install ceiling panels. The lip is stapled into the top of the truss and the next panel sits in the C-channel. Another popular method of installing gypsum ceiling panels on a mobile home are these integrated strips. They are glued over the seams of the panels.
How do you remove battens from a mobile home ceiling?
You will need to loosen one of the ends and then use a serrated blade to slide behind it to loosen the adhesive and pull the strip down. Many ceilings in older mobile homes have flat battens (also called splines or strips) that cover the seams where each panel meets.
What brand of ceiling panels are used in mobile homes?
The most common brand is SeaSpray Brand Hi-Strength MVR Ceiling Panels by National Gypsum but many mobile home suppliers sell them as C-Spray instead of SeaSpray. I’m not sure if that’s a licensing thing or if it’s a whole different product to be completely honest.
What is the standard size of a mobile home ceiling?
One of the most common mobile home ceiling designs uses 4-foot wide ceiling panels screwed into the roof trusses every 24″ or 16″ (the typical space between the roof trusses). A flat plastic trim covers where two seams meet and rosettes are used on the trusses in between the seams.
How do you repair a ceiling in a mobile home?
0:403:07How To repair Mobile Home ceiling. - YouTubeYouTubeStart of suggested clipEnd of suggested clipSame thing we're gonna small sheets it's going to go to here. Place that section reinstall the lightMoreSame thing we're gonna small sheets it's going to go to here. Place that section reinstall the light we're install insulation and all that kind of stuff spray. From old.
How do you repair a old mobile home ceiling?
1:273:27Mobile Home Ceiling Repair Instructional Video - YouTubeYouTubeStart of suggested clipEnd of suggested clipWith deck screws but ledger locks must be used to permanently fasten the band joist to the wallMoreWith deck screws but ledger locks must be used to permanently fasten the band joist to the wall framing. After the band joists are installed lay out where the ceiling joists will be hung. Then measure
What is the best way to repair popcorn ceiling?
0:472:40How To Repair Popcorn Ceiling Texture - YouTubeYouTubeStart of suggested clipEnd of suggested clipUsing a sweeping back-and-forth motion feathering the texture into the surrounding. Area shake theMoreUsing a sweeping back-and-forth motion feathering the texture into the surrounding. Area shake the can periodically during use for large repair.
How much does it cost to fix a ceiling in a mobile home?
When repairing your mobile home ceiling, costs range from $150 to $900. Mobile home ceilings are at risk of cracks and holes because they do not always have the best levels of strength and durability. There is also a risk of leaks if holes appear in the roof.
What material is used for mobile home ceilings?
Most mobile homes and older manufactured homes (or lower end, more affordable models) have ceilings made of gypsum instead of drywall. Gypsum is a natural mineral used for blackboard chalk, drywall, and wallboards in mobile homes.
What do you use for a trailer ceiling?
Metal Ceiling Liner: cladding your ceiling with metal makes a great visual inside the trailer as well as adds protection against dents, dings, scuffs, splashes, etc. White Vinyl Ceiling: white vinyl is an economical choice for adding protection but also creating a clean look inside the interior of the trailer.
Is it better to spray or roll popcorn ceiling?
Spray Painting Popcorn. Painting ceiling texture with only a roller is fine if the ceiling's already been painted. Painted popcorn is usually less brittle and doesn't break off onto the roller as much as unpainted texture. If the ceiling is unpainted, spraying is the best way to go, and it's a lot faster than rolling.
Does all popcorn ceiling have asbestos?
Popcorn ceilings generally contain between 1 and 10 percent asbestos. While 1 percent may seem insignificant, it's important to note that any percentage of asbestos in a popcorn ceiling is cause for concern and should be addressed.
Can you touch up popcorn ceiling?
Because restoring textured surfaces is far more challenging than patching and repainting a smooth surface, touching up a popcorn ceiling is something that not every DIYer can tackle himself. However, with the right guidance you can do an excellent job that won't look like a repair.
How much weight can a mobile home ceiling hold?
How much weight can a mobile home ceiling hold? The ceilings of mobile homes can generally take the same amount of weight as the roof can hold, which is at least 20 pounds per square foot. More up-to-date, higher-quality mobile home ceilings will be able to hold upward of 30 pounds.
What is the cheapest way to replace a ceiling?
Cheapest: A novice do-it-yourselfer can install a snap-together tin ceiling, which screws directly to the existing drywall or plaster ceiling. Expect to pay $6.50 for a 1-pound pack of 2-inch #6 drywall screws. Tin ceilings look best finished with molding.
How much does it cost to put a rubber roof on a mobile home?
Rubber Roofing For a single-wide structure you are looking at an average cost of $1,175 to $2,295, and for a double-wide mobile home, the cost should be $1,595 to $3,610. If it is speed and relative affordability you are after for your roof replacement, then rubber roofing is definitely an option to consider.
Can you put drywall on the ceiling of a mobile home?
Most mobile homes are constructed to give an eight-foot ceiling height, so the drywall sheets should fit between the floor and ceiling. If you decide to replace the ceiling panels as well, then you should drywall the ceiling before you tackle the walls.
How do you repair a fiberboard ceiling?
Restoration-conservationist approach to fiberboard repairMake a flour and water paste, mix up fibers from a scrap of extra fiberboard of the same or similar brand and model,fill the gouge with a patch of fiberboard material and paste or a cut and trimmed patch to fit,press until dry, polish the surface,More items...
Do mobile homes have ceiling joists?
Mobile home walls are constructed much like the floors. They consist of a framework, usually in H-shapes, of wooden joists and supports. The space in between these joists forms cavities that are also used for insulation material. Both the interior and exterior of the walls are then covered in panels.
How do you find a ceiling joist in a mobile home?
0:002:16Locating Studs In Mobile Homes Plus Other House Home Building Walls ...YouTubeStart of suggested clipEnd of suggested clipToday I'm going to show you my favorite ways of finding studs.MoreToday I'm going to show you my favorite ways of finding studs.
Before You Begin
It’s not difficult to patch a popcorn ceiling, but it does require a little bit of prep work ahead of time. With a step-by-step like this one, most DIYers are qualified to tackle this task. Like any home renovation project, make sure you have all the tools and supplies you will need before you begin so you don’t have to stop partway through.
How to Fix a Popcorn Ceiling (6 Steps)
If you’ve ever watched someone patch a popcorn ceiling on those home renovation shows, you will notice one of two things. Either the room they are working in will be empty, or plastic will cover any furniture. This is due to the sheer amount of dust that will result from this project. It also protects from any damage from paint splatter at the end.
Fixing a Small Hole in the Ceiling
If you find only a small hole in the ceiling once you scrape the old texture off, then it’s not necessary to cut a huge chunk out. Filling the hole with joint compound and embedding a piece of tape across the hole will be sufficient. After embedding the tape, make sure you still give it a final coat of compound to smooth it out.
Conclusion
As you can see in this straightforward step-by-step, it doesn’t take any special training to patch a popcorn ceiling. However, if this is your first time doing any drywall work, prepare for a little bit of frustration. Mudding and taping is an art, but the beauty of popcorn texture is that it hides many of the imperfections.
Can You Repair or Touch Up a Popcorn Ceiling?
You can easily perform small repairs or touch-ups to popcorn ceiling damage. There are many different options available to you that vary in cost and effort needed.
How To Fix Your Popcorn Ceiling
Small damages can easily be repaired or covered by using a popcorn ceiling patch, spray, or a roller. You can find these tools at the nearest Home Depot and each requires minimal effort to use.
Cost To Repair Popcorn Ceiling
Hiring a contractor to fix popcorn ceiling damages is expensive, but it ensures that the problem is permanently repaired.
How To Repair a Popcorn Ceiling With a Roller
Step one: Lay down a tarp on the floor underneath the damaged ceiling. Cover any other surfaces as needed.
How To Repair a Popcorn Ceiling With a Patch
Step one: Cover all surfaces. You can lay a drop cloth or tarp underneath the damaged area, but you might want to cover the walls and furniture as well.
How To Repair a Popcorn Ceiling With Spray
Step one: Cover any surfaces. The walls, floor, and furniture could be accidentally sprayed if uncovered.
How To Touch Up a Popcorn Ceiling
Touching up a popcorn ceiling doesn’t have to be an extensive repair. As houses age, the ceiling will go through natural wear and tear. Water leaks or humidity may cause stains or other small damages.
What is the ceiling made of in a mobile home?
Most mobile homes and older manufactured homes (or lower end, more affordable models) have ceilings made of gypsum instead of drywall. Gypsum is a natural mineral used for blackboard chalk, drywall, and wallboards in mobile homes.
How wide is a mobile home ceiling?
One of the most common mobile home ceiling designs uses 4-foot wide ceiling panels screwed into the roof trusses every 24″ or 16″ (the typical space between the roof trusses). A flat plastic trim covers where two seams meet and rosettes are used on the trusses in between the seams.
How thick is gypsum for mobile home?
The gypsum panels will usually run the entire width of a single wide or half the double wide. They are typically 16″, 24″, or 48″ wide and 5/16″ or 1/2″ thick. There are four major disadvantages of older gypsum ceiling panels.
What are the disadvantages of gypsum ceilings?
There are four major disadvantages of older gypsum ceiling panels. First, they are delicate and easy to damage. Secondly, the older mobile home ceilings tend to sag or become unattached from the trusses. Finally , they also tend to turn yellow.
What is a batten in a mobile home?
Many ceilings in older mobile homes have flat battens ( also called splines or strips) that cover the seams where each panel meets. However, some builders were a bit more creative and gave their ceilings a mini-coffered design with dimensional beams, aka false beams.
What are false beams in mobile homes?
However, some builders were a bit more creative and gave their ceilings a mini-co ffered design with dimensional beams, aka false beams.
Can you use false beams on a coffered ceiling?
In order to use shorter ceiling panel lengths and give the home a custom coffered ceiling design, some manufactured home builders installed false beams that span straight down the middle of the ceiling and down each side to cover the ceiling panel seams.
