how to repair power window regulator

Power Window Regulator Repair Steps

• Check The Fuse. Make sure before starting the process; you check the fuse. ...
• Get The Proper Tools. In order to get started, you will need specific tools – sockets, screwdrivers, drills, and a service manual or instructions from your manufacturer or mechanic.
• Remove the Trim Panel. ...
• Connect Leads to the Voltmeter. ...
• Analyze Voltmeter Readings. ...

Full Answer

How to change power window regulator?

• Insert one of the bolts into the window regulator
• Push the regulator into the door
• Hang the regulator by its bolt
• Tighten the last five 10mm bolts into the regulator
• Remove the painter's tape from the window
• Lower the window onto the regulator
• Connect the window motor lead
• Connect the window switch to the panel and test the regulator

How to diagnose a broken power window regulator?

Top 4 Bad Window Regulator Symptoms

1. Window Button Fails. If you are unable to lower or raise a door window by pressing the button for it, then you probably have a bad power window regulator.
2. Stuck Window. There may be a situation where the window will lower or raise a little bit, but then get stuck about halfway in between where you wanted it ...
3. Strange Noises. ...
4. Window Drops. ...

How much does window regulator repair cost?

The labor time to replace a window regulator is also estimated at 1.3 hours. A factory regulator costs about $120, and an AVI part costs about $85. The total cost to complete the job of replacing the regulator would be about $250 using OE parts, or about $215 using aftermarket parts.

How to replace a power window motor and regulator?

Remove The Door Panel

1. Remove two bolts from behind the door handle.
2. Pop off a bezel around the door handle using a plastic pry tool. The door panel needs to be removed to gain access to the window motor and regulator.
3. Next, lift out the window switch panel.
4. After that, remove two bolts hidden behind two plastic plugs.

More items...

Can power window regulator be repaired?

A shop will charge you at least a few hundred dollars to replace the motor/regulator, but you can do a window regulator repair and power window repair yourself in about four hours. Regulators are available online or at auto parts stores.

Can a power window motor be repaired?

In some cases, a power window motor can be repaired and doesn't require replacements, thus saving YOU money! When the problem stems from broken plastic or rubber inside the window motor casing, Power Window Repair can often replace or repair those parts, giving your power window motor new life for years to come.

What tools do you need to fix a window regulator?

Silicone spray works well.PLEASE WEAR SAFETY. GLASSES! Tools required for removal and.installation of window regulator and. motor assembly: ... • Panel retainer remover. • Magnet. ... • T-20 Torx socket or driver. • 1/4” socket or driver. ... • 5/16” or 8mm socket or driver. • Punch. ... • Small hammer. • Flat-blade screwdriver or plastic pry.

What causes a window regulator to fail?

The window regulator can overheat from excessive use and stress over time, which can lead to a complete failure of the regulator. If a motor starts to overheat, the best practice would be to let it cool down before trying to use it again. Freezing temperatures can cause a window to disconnect from a window regulator.

How do you fix a window regulator motor?

6:5818:59How to Replace a Window Regulator Motor (DIY) - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd products you're going to need and i like to keep things nice and simple we have a drill andMoreAnd products you're going to need and i like to keep things nice and simple we have a drill and drill bits to drill out the three rivets holding the old motor to the regulator.

How much does it cost to fix a window regulator?

On average, a new window regulator will cost between $300 and $450 and sometimes more, depending on the make and model of the car you drive. Windows that move most frequently, namely the driver's side front window, will require replacement before the others.

How do you get a power window up when stuck down?

Troubleshooting a Stuck Electric Car Window Press and hold the window switch in a closed position. Keep the button depressed and push the side that closes the window. Open and slam the car door while the window button is depressed. Try it a few times until the window opens.

How do you manually roll up a power window?

Grip the window between your palms and slide it up. Stand at the end of the open door and place one palm on the outside of the window and the other palm facing it on the inside of the window. Pressing the glass firmly between your palms, slowly move your hands up to raise the window.

How do you know if it's the window regulator or the motor?

Power window goes down, but not up, the motor is not running when the switch is in "UP" position. Window motor runs but the window jams or doesn't move: In this case, we know that the window switch, the wiring and the window motor work. That means the problem is with the window regulator.

How do I know if my window regulator is broken?

Symptoms and Remedies to Window Regulator Failure in Your CarGrinding or Clicking Noises While Rolling Up the Window. The window regulator, or motor, is located in the door of your car. ... Window Won't Stay Rolled Up or is Off-Center. ... The Button Doesn't Work the First Time. ... Window Seems Sluggish or Too Quick. ... How We Can Help.

How do you test a window regulator?

1:176:58How to Diagnose if the Window Motor or if the Window Regulator is BadYouTubeStart of suggested clipEnd of suggested clipSo to test the window motor you'll want to connect the test seats to the window motor connection.MoreSo to test the window motor you'll want to connect the test seats to the window motor connection. But as you can see here the alligator clips will not always fit while it'll fit one but the second.

Why won't my power window go up or down?

When a power window won't go up or down, the issue could be with the window motor. Without starting the car, turn the ignition to the accessory position. Engage the switch for the affected window and see if the voltmeter (if your vehicle has one) in the instrument panel moves even a slight amount.

How much does it cost to fix a power window motor?

The average time to replace a power window motor is 2.1 hours. That averages out to roughly $120 to $150 in labor time plus the cost of the motor itself. This can usually bring the entire job to a total of anywhere from $200 to $300, depending on make and model.

How much does it cost to replace power window motor?

The Best in Auto Repair The average cost for window regulator motor replacement is between $283 and $384. Labor costs are estimated between $92 and $116 while parts are priced between $190 and $267. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location.

How do I know if my power window motor is bad?

Symptoms of a Bad or Failing Window Motor / Regulator AssemblyIt takes multiple presses to roll the window up or down.Window speed is slower or faster than usual.Clicking from the door when the window rolls up or down.Power window won't stay up or is crooked.

Can you replace just the window motor without removing regulator?

If you are only replacing the power window motor and not the regulator itself, you will need to disconnect it and connect it to your new power window motor. Visually inspect the two to make sure the new motor matches the old one, then swap the regulator.

How to repair a window regulator?

Start the power window regulator repair by removing the trim panel fasteners to gain access to the switch. Remove the trim panel and the vapor barrier. Then, get into the door panel and disconnect the power connector to the window motor.

What happens if the power window goes down but cannot rise again after being lowered?

If the power window goes down but cannot rise again after being lowered, the motor works, but the driver’s side door’s main switch does not work to control the vehicle’s windows. If wiggling the switch and pressing the power button multiple times does not work, you have to fix the electrical system.

What to do if your window is slow going up?

Window Is Slow Going Up. If the window is slow going up, you can have to look into the power window regulator repair for your vehicle. Lubricating the window channels is key to having the window work effectively using a special lubricant.

Why does my window motor get stuck?

If the window motor will continue to run and gain excess power, but the window jams and gets stuck during use. This means that the wiring and the window regulator are the problems. The window regulator repair can help fix the window motor gear and the glass connected to the regulator.

How does an electric window motor work?

When the driver or the passenger pushes the button on the door to change the window’s position , this turns on the electric motor. This electric window motor then uses the regulator to adjust the window’s position.

Why is my window not moving?

If your window is not stuck and you are able to move the windows, the problem might not be the window, but the power window regulator mechanism. This could be a clear sign of a failing power window regulator and a damaged window motor. These noises could sound like squeaking, grinding, or clunking, which can show the immediate need to look into the power window regulator repair cost.

Why won't my window move up and down?

Over time, the window tracks can get filled with outside dust, debris, and dirt, causing the window to not be able to move up and down smoothly. If this is the case, the power window regulator repair cost will be much higher.

How long does it take to repair a window regulator?

A shop will charge you at least a few hundred dollars to replace the motor/regulator, but you can do a window regulator repair and power window repair yourself in about four hours. Regulators are available online or at auto parts stores.

How do I replace a window motor?

Start by removing the window-to-regulator bolts (have someone hold the glass while you do this). Then remove the glass by tilting it away from the door and lifting it out.

How to repair a window switch?

Photo 1: Remove the switch panel. Pry out the switch panel and disconnect the electrical connectors to begin power window repair. Then remove the door trim panel. Photo 2: Test the motor connector. Reconnect the switch panel and attach the voltmeter test leads to the motor connector. Then toggle the window switch.

Can you fix a broken power window?

A broken power window can be an expensive repair, but if you have basic auto repair tools and access to an online service manual you can fix it yourself and save big bucks.

Power window repair and replacement services

Our trained technicians at Safelite will ensure that you receive the best parts and service for your power window regulator. When we fix your side power window, the motor will work exactly how it used to before it needed service. The best part: We’ll fix your window fast and efficiently, so you can get back to using it quickly.

The best choice for power window repair

You operate your power windows more often than you probably think. From rolling them down to feel a fresh breeze, to grabbing lunch at a drive-through, to withdrawing money at a bank, you use power window switches constantly. We know how important it is to correctly fix your broken power window before it becomes a major inconvenience.

Manual window regulator repair

We service more than just newer makes and models. If you have an older vehicle and your manual window regulator won’t work, Safelite is the right place to get it fixed. Our trained technicians will repair or replace your manual window regulator with top-quality parts backed by our nationwide warranty.

What is a power window regulator?

A power window regulator is the mechanical apparatus that raises and lowers the window. A power window motor is needed to power the power window regulator. Without a motor, the window would need to be manually opened via a window crank. Power window regulators and motors are housed inside a car’s doors. Out of sight and out of mind, window ...

What is the phone number for a power window regulator?

Keep yourself and your passengers safe and comfortable in your car. For power window repair, call 833-974-0209 or request an appointment online to learn more.

What does it mean when a window is rolled up?

Squeaky, scraping or otherwise abnormal noises when the window is being rolled up or down. The window doesn’t raise or lower evenly – it appears crooked. The window slips partially or falls inside the door. The window motor runs, but the window stays stationary. The window is abnormally slow to open or close.

Why does my window not go up?

A window that goes down but not up may indicate a problem with the switch or your vehicle’s power circuit. A window that jams or doesn’t move when the motor runs, may be a sign of a mechanical problem with the power window regulator.

Why are power windows important?

Operational power windows help keep passengers safe from the elements and provide structural integrity to your vehicle.

Do power windows wear out?

Most modern cars are equipped with power windows that roll up or down with the touch of a button. Unfortunately, power windows may wear or break over time. Fortunately, many of our local service professionals repair or replace power window regulators!