
- Obtain a whole piece of an above-ground pool wall. For the do-it-yourselfer, this may be the most difficult part of the repair. ...
- At the very least, get 30 stainless nailhead steel fasteners and four sets of steel material channels. ...
- On the inside of the pool, insert the new wall piece against the old wall. ...
- Make holes through the metal channels that run along the edges of the wall piece. ...
- Bolt the pieces together using the drilled holes. Check to see that the nuts and bolts are securely fastened. ...
- From top to bottom, secure the bolts using duct tape on the inside. Repeat the procedure as done with the pool’s existing wall bolts.
Can you repair a rusted above ground pool?
That's why it's important to always keep up with above-ground pool wall repair. There are different reasons a pool can become rusted, including leaking gaskets, holes in the pool liner, an overfilled pool or even water behind the pool wall. Don't worry, though – you can repair an above-ground pool with rust on the pool walls.
How do you keep a pool liner from rusting?
After you sand and paint the area, use wall foam to protect the liner from oxidation. If there's rust on the lower third of the pool wall, there's more cause for concern. Rust in the lower part of the pool wall is less common because the weight of the water in the pool applies pressure.
How do I know if my pool wall has rust?
If the rust is not surface level, though, then you are dealing with a more serious case. If you can flake off the rust in layers, then that means you're dealing with deep corrosion. In order to test if the rust is causing corrosion, get a screwdriver and see how deep the rust goes. If the rust is just coming off the pool wall, you're OK.
Is rust on galvanized steel pool walls a problem?
Rust on galvanized steel pool walls has always been a concern however with so many salt water pools now in operation, there has been an increase in the number of pools with extensively rusted surfaces.

Can you fix a rusted pool wall?
0:001:28How To Fix Rust On Pool Walls? - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then a regular paint isn't good enough you need to use a more expensive galvanized steel paintMoreAnd then a regular paint isn't good enough you need to use a more expensive galvanized steel paint to paint over the entire wall surfaces. And that will dramatically reduce how quickly that rust.
Can you fix an above ground pool wall?
There are different reasons a pool can become rusted, including leaking gaskets, holes in the pool liner, an overfilled pool or even water behind the pool wall. Don't worry, though – you can repair an above-ground pool with rust on the pool walls.
How do you repair rust in an above ground pool?
0:343:24Protecting Your Liner From a Rusty Wall for Above Ground PoolsYouTubeStart of suggested clipEnd of suggested clipWhat we're doing is we're covering it up so that those rusty holes don't get on our liner. And rubMoreWhat we're doing is we're covering it up so that those rusty holes don't get on our liner. And rub on our liner. And put a hole in our liner. Okay that's what this is about once that wall starts rust.
How do you fix rusty pool rails?
0:251:50Q&A: How can I fix a Rusted metal pool rail above ground poolYouTubeStart of suggested clipEnd of suggested clipYou could go with the composite. They probably and I don't know offhand. Who makes a compositeMoreYou could go with the composite. They probably and I don't know offhand. Who makes a composite replacement but I imagine they do but you could also go with aluminum.
How do you remove rust from pool walls?
2:003:39Removing Rust Stains from your Pool - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd one good trick I use if there's a lot of sun glare I sprinkle some dish soap mixed with water inMoreAnd one good trick I use if there's a lot of sun glare I sprinkle some dish soap mixed with water in the pool.
How long do above-ground pool walls last?
The thicker, fully printed liners will last on average between five and eight years. The thinner, standard solid blue liners usually last between two and five years. So, it's much better to spend more for the nicer one.
What are above ground pool walls made of?
steelAnother excellent option for your above-ground swimming pool is resin. With a resin pool, the walls are still made from steel, but the top rails, uprights, tracking system and caps are made from resin or resin and plastic materials.
What causes pool walls to collapse?
A common cause of pool collapse is a build up of snow, rainwater, and ice on the pool's cover. The weight of the elements can be too heavy for the pool walls to contain, causing them to fracture and collapse.
How do you reinforce a pool wall?
2:205:28How To Repair Rusty Pool Walls - YouTubeYouTubeStart of suggested clipEnd of suggested clipWall apply an all-purpose silicone caulk around the perimeter of hole place the new sheet metal overMoreWall apply an all-purpose silicone caulk around the perimeter of hole place the new sheet metal over the hole then drill a hole into one of the corners and through the pool wall.
Can I paint my above ground pool top rails?
You may be wondering, can you paint above-ground pool rails and walls? The short answer is yes!
Do above ground pools rust?
Rust and corrosion are caused by moisture coming into contact with metals for a prolonged period of time. In particular, above ground pools can pose a direct problem because they are almost always in areas that will come into contact with moisture.
Does stainless steel rust in pool water?
In most aquatic environments, stainless steel will not rust or stain, even after many years of service. There are some chemicals that can corrode stainless steel, but these chemicals do not appear in high enough concentrations in pool environments to affect this alloy.
What is rust on pool walls?
Most of the time the discovered rust on the inside of the pool wall is just surface rust and not much of an issue. With surface rust you can maybe get some sandpaper, sand the rusty areas smooth, and then use that can of Rust-Oleum you found and the wall is good to go.
How do I drill holes in a pool wall?
Line up the metal channels to the edge of the wall piece and drill holes all the way through. You’ll be drilling holes from the inside of the pool through the inside and outside steel channel, the wall piece , and the existing wall from top to bottom. Bolt everything together through the drilled holes.
Why do people replace their pool?
Sometimes pool owners will replace their pool because its top rails are too rusty or some of the uprights and pieces of bottom track have rusted out. Mostly though, people decide that their pool is dead because it has a rusty or corroded wall. And this is what makes an above ground pool no good anymore as it’s the wall that holds all the water.
How long should a pool wall be?
The wall piece should be at least 4’ long or long enough to cover all the bad areas of your pool wall. Get at least 30 stainless flathead steel bolts and nuts and four pieces of metal steel channel. You’ll use these to bolt your new piece of wall to your existing pool wall.
Why is there a hole in the bottom of my pool?
The reason a hole lower down is concerning is because the water creates more outward pressure there at the bottom.
What happens if a pool doesn't hold up?
Though, with this option, you may not be so lucky, because if it doesn’t hold, you’re out the cost of the new liner, the installer (if you didn’t do it yourself), and all the lost water and chemicals.
Can a rust hole in a pool wall cause a blowout?
A rust hole at the bottom of the wall is much more likely to tear open under pressure and cause a “blowout” than one nearer to the top. In most cases a small hole towards the bottom of the wall won’t cause a blowout. I usually tell the pool owner about it, tape some tin over it, install a new liner and it holds.
A rock or something from the lawnmower hit it
This is very common. Sometimes you won’t know it happened at the time, but when you see the hole, you can tell how it happened.
Something sharp was thrown and hit the pool wall
This you can tell by inspecting the hole and the way the metal folds inward. Kids will be kids and throw stuff. Kids may also not tell you that they hit the pool while playing.
Something sharp punctured the wall from inside the pool
This is not good. Again, kids are probably the culprit here but you never know. Pools and alcohol make a fun mix and things can get crazy.
Someone shot my pool!
This may be more common than you think. In the 35 years of me working on above grounds, I’ve done more than a few wall repairs from gunshots. I even had one from a cross-bow which was kind of cool.
The hole was caused by an outside rust spot
For one reason or another, a pool wall can get a spot of rust on the exterior. This can be from a manufacturer’s defect in the wall or a scratch that removed the protective coating.
FIX FROM A ROCK FROM MOWING THE LAWN OR SOMETHING SHARP WAS THROWN AT THE POOL AND MADE A HOLE
Step 1 – Make sure the liner wasn’t damaged as well – In many cases, a hole can be made in the wall of the pool, but not the liner.
ADVANCED ABOVE GROUND POOL WALL REPAIR
If you have discovered that the inside of your pool wall is rusted through badly, but only in one area, then you can fix this by doing an extreme repair.
